HomeMy WebLinkAboutFellows Shredder Oil_SDS Safety Data Sheet
Section 1: Identification
1.1 Product Identifier
Product Name
Fellowes Item Number
: Fellowes Shredder Oil
: 35250
1.2 Relevant Identified Uses of the Substance or Mixture and Uses Advised Against
Use of the substance/mixture
: Lubricant
1.3 Details of the Supplier of the Safety Data Sheet Company
Address
Telephone Fax
Toll Free
Website
: Fellowes, Inc
: 1789 Norwood Avenue
Itasca, IL 60143-1095 USA
: 630.893.1600 : 630.893.1648
: 800.945.4545
: fellowes.com
SECTION 2: Hazard(s) Identification
2.1 Hazard(s) Identification
This product is NOT classified as hazardous according to 29 CFR 1910, amended to conform to the United Nations’ Globally Harmonized System of
Classification and Labelling of Chemicals (OSHA/GHS); SOR/88-66, The Canadian Controlled Products Regulations (CRP); and/or NOM-002-SCT-2003 (Mexico). However, vegetable oil (in mist form) is known to be listed as OSHA CFR 1910.1000 air contaminant. Occupational exposure limits are subsequently provided in Section 8 of this SDS.
SECTION 3: Composition / Information On Ingredients
3.1 Substance
Name CAS No.
EINECS No.
: Canola Base Lubricating Oil : 120962-03-0
: 601-748-6
Name Product Identifier Maximum Weight
Canola Base Lubricating Oil (CAS No.) 120962-03-0 >99% Vegetable
Page 1 of 6
Fellowes, Inc. Reviewed on 03/04/15 www.fellowes.com
Safety Data Sheet
SECTION 4: First-Aid Measures
4.1 Description of First Aid Measures
First-aid measures after inhalation
First-aid measures after skin contact
First-aid measures after eye contact First-aid measures after ingestion
: Remove the victim into fresh air. Consult a doctor/medical service.
: Remove excess with cloth or paper. Wash thoroughly with soap and water.
: Immediately flush with plenty of water for 15 minutes. Consult a doctor/medical service. : Seek medical attention immediately. Do not induce vomiting, (vomiting may cause aspiration into
lungs resulting in chemical pneumonia).
SECTION 5: Fire-Fighting Measures
5.1 Extinguishing Media
Dry chemical, water fog, carbon dioxide, or foam.
5.2 Special Hazards Arising From the Substance or Mixture
Unusual fire and explosion hazards: None
5.3 Advice For Firefighters
Do not use water except as fog.
5.4 National Fire Protection Association (NFPA) – Hazard Identification
Health 0 Flammability 1 Reactivity 0
SECTION 6: Accidental Release Measures
6.1 Clean Water Act / Oil Pollution Act
This product may be classified as an oil under Section 311 of the Clean Water Act, and under the Oil Pollution Act. Discharges or spills into or leading to surface waters that cause a sheen must be reported to National Response Center (1-800-424-8802). 6.1.1 Steps To Be Taken In Case Material Is Released Or Spilled
Recover free product. Add sand, earth, or other suitable absorbent to spill area. Minimize skin contact. Keep product out of sewers and watercourses by diking or impounding. Advise authorities if product has entered or may enter sewers, watercourses, or extensive land areas. Assure conformity
with applicable governmental regulations.
Page 2 of 6
Fellowes, Inc. Reviewed on 03/04/15 www.fellowes.com
Safety Data Sheet
SECTION 7: Handling and Storage
7.1 Precautions for Safe Handling Use product with caution around heat, sparks, pilot lights, static electricity, and open flame.
7.2 Procedures For Clean-up
Transfer bulk of mixture into another container. Absorb residue with an inert material such as earth, sand, or vermiculite. Sweep up and dispose as solid waste in accordance with Local, State, and Federal regulations.
7.3 “Empty” Container Warning
“Empty” containers retain residue (liquid and/or vapor) and can be dangerous. Do not pressurize, cut, weld, braze, solder, drill, grind or expose such containers to heat, flame, sparks, static electricity, or other source of ignition; they may explode and cause injury or death.
Do not attempt to refill or clean containers since residue is difficult to remove. “Empty” drums should be completely drained, properly bunged and promptly returned to a drum reconditioner. All other containers should be disposed of in an environmentally safe manner and in accordance with governmental regulation.
7.4 Waste Disposal Dispose of in accordance with all applicable Federal, State and Local regulations.
SECTION 8: Exposure Controls / Personal Protection
8.1 Exposure Limit For Total Product
5 mg/m3 For oil mist (aerosol) for an 8-hour workday. 8.2 Basis OSHA Regulation CFR 1910.1000 and recommended by the American Hygienists (ACGIH). ACGIH states that the air is to be sampled by a method
that does not collect vapor; in addition, it lists a 10 mg/m3 STEL. 8.3 Ventilation
Use local exhaust to capture vapor, mists or fumes, if necessary. Provide ventilation sufficient to exceeding recommended exposure limit or buildup of explosive concentrations of vapor in air. No smoking or use of flame or other ignition source.
8.4 Respiratory Protection
Use supplied-air respiratory protection in confined or enclosed spaces, if needed.
8.5 Protective Gloves
Use chemical-resistant gloves, if needed, to avoid prolonged or repeated skin contact. 8.6 Eye Protection
Use splash goggles or face shield when eye contact may occur.
8.7 Other Protective Equipment
Use chemical-resistant apron or other impervious clothing, if needed, to avoid contaminating regular clothing, which could result in prolonged or repeated skin contact.
Page 3 of 6
Fellowes, Inc. Reviewed on 03/04/15 www.fellowes.com
Safety Data Sheet
8.8 Personal Hygiene Minimize breathing vapor, mist or fumes. Avoid prolonged or repeated contact with skin. Remove contaminated clothing; launder or dry-clean before
re-use. Remove contaminated shoes and thoroughly clean before re-use; Discard if oil soaked. Cleanse skin thoroughly after contact, before breaks and meals, and at end of work period. Product is readily removed from skin by waterless hand cleaners followed by washing thoroughly with soap and water.
SECTION 9: Physical and Chemical Properties
9.1 Information On Basic Physical and Chemical Properties
Physical state Appearance
Color
Odor pH
Evaporation rate Melting point
Boiling point Flash point
Flammable Limits %
Vapor pressure Vapor density
Specific gravity (water = 1)
Solubility in water Viscosity SUS at 100 F
Volatile Stability
: Liquid : Thin Liquid
: Light Amber (Golden)
: Bland : N/A
: 0 : N/A
: N/A : > 540° F (Method Used) Cleveland Open Cup
: N/A
: N/A : N/A
: 0.905
: 0 at 20° C : 190
: 0 : Stable under normal conditions
SECTION 10: Stability and Reactivity
This product is stable and will not react violently with water. Hazardous polymerization will not occur. Avoid contact with strong oxidants such as liquid chlorine, concentrated oxygen, sodium hypochlorite, calcium hypochlorite, etc., as this presents a serious explosion hazard.
Page 4 of 6
Fellowes, Inc. Reviewed on 03/04/15 www.fellowes.com
Safety Data Sheet
SECTION 11: Toxicological Information
11.1 Nature Of Hazard and Toxicity Information
Repeated and prolonged overexposure to oil mists may result in droplet deposition, oil granuloma formation, inflammation and increased incidence
of infection. 11.2 Toxic and Hazardous Ingredients None
SECTION 12: Ecological Information
Ecological effect testing has not been conducted on this product. Do not discharge this product into public water or waterways unless authorized by a
National Pollution Discharge Elimination system (NODES) Permit issued by the Environmental Protection Agency (EPA). An environmental fate analysis has not been conducted on this specific product. However, plants and animals may experience harmful or fatal effects when coated with petroleum-based products. Petroleum-based (mineral) lube oil will normally float on water. In stagnant or slow-flowing waterways, an oil layer can
cover a large surface area. As a result, this oil layer might limit and eliminate natural atmospheric oxygen transport into the water. With time, if not removed, oxygen depletion in the waterway might be enough to cause a fish kill or create an anaerobic environment.
SECTION 13: Disposal Considerations
13.1 Waste Treatment Methods
Options for disposal of this product may depend on the conditions under which it was used. To determine the proper method of disposal, refer to RCRA (40 CRF 261), as well as Federal EPA and state and local regulations. Please refer to section 5, 6 and 15 for additional information.
SECTION 14: Transport Information
UN Number US DOT (United States Department of Transportation): Not Regulated IMO/IMDG (International Maritime Dangerous Goods): Not Regulated
IATA (International Air Transport Association): Not Regulated ADR (Agreement on Dangerous Goods by Road (Europe)): Not Regulated RID (Regulations Concerning The International Transport of Dangerous Goods (Europe)): Not Regulated
AND (European Agreement Concerning The Carriage of Dangerous Goods by Inland Waterways): Not Regulated
Page 5 of 6
Fellowes, Inc. Reviewed on 03/04/15 www.fellowes.com
Safety Data Sheet
SECTION 15: Regulatory Information
15.1 US Federal Regulations The following information may be useful in complying with various state and federal laws and regulations under various environmental statutes: threshold planning quantity (TPQ), EPA regulation 40 CFR 355 (SARA Sections 301-304) no TPQ for product or any constituent greater than 1% or 0.1% (carcinogen). 15.2 Toxic Chemical Release Reporting, EPA Regulation 40 CFR 372 (SARA Section 313)
No Toxic chemical is present greater than 1% or 0.1% (carcinogen).
15.3 Hazardous Chemical Reporting, EPA Regulation 40 CFR 370 (SARA Section 311-312) EPA Hazardous Classification Code: Not applicable
15.4 Toxic Substance Control Act (TSCA)
This product does not contain polychlorinated biphenyls (PCB’s) All components of this product are listed on the U.S. TSCA Inventory.
This product does not contain detectable amounts of any material listed by the state of California as known to cause reproductive toxicity. 15.5 WHMIS
Not a controlled product. 15.6 CEPA (Canadian Environmental Protection Act) All components of this product are on the Domestic Substance List (DSL) or are exempt.
SECTION 16: Other Information
The information contained in the Safety Data Sheet is believed to be correct and used as a guide.
Page 6 of 6
Fellowes, Inc. Reviewed on 03/04/15 www.fellowes.com